Methods for computing the electrostatic fields influence on heat transfer to the MS-20 aviation motor oil exposed to its forced convection
Published: 02.07.2024
Authors: Altunin V.A., Lvov M.V., Yusupov A.A., Shchigolev A.A., Gortyshov Yu.F., Koreev E.P., Yanovskaya M.L.
Published in issue: #7(151)/2024
DOI: 10.18698/2308-6033-2024-7-2373
Category: Aviation and Rocket-Space Engineering | Chapter: Thermal, Electric Jet Engines, and Power Plants of Aircrafts
The paper presents new methods to compute the heat transfer coefficients and the relative heat transfer coefficients. They are based on the results of experimental studies on the influence of transverse electrostatic fields on the thermal processes in the MS-20 aviation motor oil. The oil was exposed to forced convection in an annular channel at different heat flux densities from the working heated metal tube, different pressures and oil pumping rates, different distances between the coaxial working needles and different applied high-voltage electrostatic voltages. These methods introduction would contribute to rapid and high-quality computation, as well as to design and creation of the new oil systems for aircraft engines with the improved performance.
EDN KVVODU
References
[1] Babkin V.I., Aleksashin A.A., Yanovsky L.S., Dunaev S.V., Khurumova A.F. Otechestvennye smazochnye masla dlya aviatsionnykh gazoturbinnykh dvigateley: problemy i perspektivy [Domestic lubricants for aviation gas turbine engines: problems and prospects]. Dvigatel — Engine, 2012, no. 5 (83), pp. 8–11.
[2] Yanovsky L.S., Kharin A.A., Babkin V.I. Osnovy khimmotologii [Fundamentals of chemotology]. Moscow, Berlin, Direkt–Media Publ., 2016, 482 p.
[3] Tryanov A.E. Konstruktsiya maslyanykh sistem aviatsionnykh dvigateley [Design of the oil systems of aviation engines]. Samara, Samara State Aerospace University Publ., 2007, 81 p.
[4] Altunin V.A., Altunin K.V., Aliev I.N., Gortyshov, Dresvyannikov F.N., Obukhova L.A., Tarasevich S.E., Yanovskaya M.L. Analiz issledovaniy elektricheskikh poley v razlichnykh sredakh i usloviyakh [Analysis of investigations of electric fields in different media and conditions]. Inzhenerno-fizicheskiy zhurnal — Journal of Engineering Physics and Thermophysics, 2012, vol. 85, no. 4, pp. 881–896 (in Russ.).
[5] Altunin V.A., Altunin K.V., Aliev I.N., Gortyshov, Dresvyannikov F.N., Obukhova L.A., Tarasevich S.E., Yanovskaya M.L. Analysis of investigations of electric fields in different media and conditions. Journal of Engineering Physics and Thermophysics, 2012, vol. 85, no. 4, pp. 959–976.
[6] Bologa M.K., Baboi N.F. Vliyanie elektricheskogo polya na teploobmena pri kipenii organicheskikh zhidkostey [The influence of the electric field on heat transfer during boiling of the organic liquids]. Elektronnaya obrabotka materialov — Electronic Processing of Materials, 1967, no. 3, pp. 30–40.
[7] Baboi R.F., Bologa M.K. Nekotorye osobennosti protsessa kipeniya v elektricheskom pole [Certain features of the boiling process in the electric field]. Elektronnaya obrabotka materialov — Electronic Processing of Materials, 1968, no. 2, pp. 57–70.
[8] Baboi R.F., Bologa M.K. Teploobmen pri kipenii organicheskikh zhidkostey v elektricheskom pole [Heat transfer during boiling of organic liquids in the electric field]. Teplo- i massoperenos — Heat and Mass Transfer, 1968, vol. 2, pp. 197–204.
[9] Bologa M.K., Grosu F.P., Kozhukhar I.A. Elektrokonvektsiya i teploobmen [Electroconvection and heat transfer]. Chisinau, Shtiintsa Publ., 1977, 320 pp.
[10] Bologa M.K., Smirnov G.F., Klimov S.M., Mayboroda A.N. Teploobmen pri kipenii v shchelevykh kanalakh pod vozdeystviem elektricheskogo polya [Heat transfer during boiling in slot channels under the influence of the electric field]. Teplomassoobmen-7 — Heat and Mass Transfer-7. Minsk, 1984, ITMO Publ., pp. 20–25.
[11] Mirolyubov N.N., Kostenko M.V., Levinshtein M.L., Tikhodeev N.N. Metody rascheta elektrostaticheskikh poley [Methods for calculating electrostatic fields]. Moscow, Vysshaya Shkola Publ., 1963, 416 p.
[12] Ostroumov G.A. Vzaimodeystvie elektricheskikh i gidrodinamicheskikh poley [Interaction of electric and hydrodynamic fields]. Moscow, Nauka Publ., 1979, 320 p.
[13] Ostroumov G.A. Elektricheskaya konvektsiya [Electric convection]. Inzhenerno-fizicheskiy zhurnal — Journal of Engineering Physics and Thermophysics, 1966, vol. 10, no. 5, pp. 683–695.
[14] Grosu F.P., Bologa M.K. Osobennosti elektrizatsii slaboprovodyashchey dielektricheskoy zhidkosti vo vneshnem elektricheskom pole [Features of electrization of a weakly conducting dielectric liquid in an external electric field]. Elektronnaya obrabotka materialov — Electronic Processing of Materials, 2006, no. 4, pp. 37–45.
[15] Grosu F.P., Bologa M.K. Elektroizotermicheskaya konvektsiya i yeye rol’ v protsesse teploobmena [Electroisothermal convection and its role in the heat transfer process] Elektronnaya obrabotka materialov — Electronic Processing of Materials, 2008, no. 3, pp. 25–35.
[16] Kronig R., Schwarz N. On the theory of heat transfer from a wire in an electric field. Applied Scientific Research, 1949, vol. AJ, pp. 35–54.
[17] Senftleben E., Braun W., Z. Phyzik, 1936, no. 102, p. 480.
[18] Kozhevnikov I.V., Bologa M.K. Vliyanie elektrogidrodinamicheskikh techeniy na intensifikatsiyu protsessov teplo- i massoobmena. Chast 1. Elektrogidrodinamicheskie techeniya i kharakteristiki odnostupenchatykh EGD nasosov [The influence of electrohydrodynamic flows on intensification of the heat and mass transfer processes. Part 1. Electrohydrodynamic flows and characteristics of single-stage EHD pumps]. Elektronnaya obrabotka materialov — Electronic Processing of Materials, 2022, vol. 58, no. 1, pp. 58–78.
[19] Kozhevnikov I.V., Bologa M.K., Grosu F.P. Vlianie elektrogidrodinamicheskikh techeniy na intensifikatsiyu protsessov teplo – massoobmena. Chast 3. Elektrokonvektsiya i elektrogidrodinamicheskie nasosy v sistemakh okhlazhdeniya i termostatirovaniya [The influence of electrohydrodynamic flows on intensification of the heat and mass transfer processes. Part 3. Electroconvection and electrohydrodynamic pumps in cooling and temperature control systems]. Elektronnaya obrabotka materialov — Electronic Processing of Materials, 2022, vol. 58, no. 3, pp. 34–54.
[20] Lvov M.V., Yusupov A.A., Altunin V.A. Rezultaty eksperimentalnogo issledovaniya teplovykh protsessov v motornykh aviatsionnykh maslakh pri ikh estestvennoy i vynuzhdennoy konvektsii [Results of an experimental study of thermal processes in aviation motor oils during their natural and forced convection]. In: Materialy Vserossiyskoy molodezhnoy nauchnoy konferentsii s mezhdunarodnym uchastiem “17 Korolevskie chteniya”, posvyashchennoy 35-letiyu so dnya pervogo poleta MKTS “Energiya — Buran” (3–5 oktyabrya 2023 g., g. Samara [Materials of the All-Russian youth scientific conference with international participation “17th Korolev Readings”, dedicated to the 35th anniversary of the first flight of the ICTS “Energia — Buran” (October 3–5, 2023, Samara)]. Samara, Samara University Publ., 2023, vol. 1, pp. 203–204.
[21] Altunin V.A., Altunin K.V., Aliev I.N., Shchigolev A.A., Platonov E.N. Razrabotka sposobov uvelicheniya resursa i nadezhnosti sistem smazki dvigateley vnutrennego sgoraniya nazemnogo transporta [Methods of life-extension and increase of reliability of lubrication systems in internal combustion engines used in ground transportation]. Izvestiya vuzov. Mashinostroenie — BMSTU Journal of Mechanical Engineering, 2015, no. 10 (667), pp. 48–58.
[22] Altunin V.A., Yusupov A.A., Shchigolev A.A., Yanovskaya M.L. Analiz problem sistem smazki porshnevykh i reaktivnykh dvigateley letatelnykh apparatov [Analysis of problems of lubrication systems for the aircraft piston and jet engines]. In: Materialy VIII Mezhdunarodnoy nauchno-tekhnicheskoy konf. “Problemy i perspektivy razvitiya aviatsii, nazemnogo transporta i energetiki” (ANTE-2015) [Materials of the VIII International scientific and technical conference “Problems and prospects for the development of aviation, ground transport and energy” (ANTE-2015)]. Kazan, Brig Publ., 2015, pp. 574−579.
[23] Altunin V.A., Altunin K.V., Shchigolev A.A., Yusupov A.A., Kokhanova Yu.S., Yanovskaya M.L. Razrabotka novykh konstruktivnykh skhem sistem smazki dvigateley dlya giperzvukovykh i aerokosmicheskikh letatelnykh apparatov [Development of new design schemes for engine lubrication systems for hypersonic and aerospace flying vehicles]. In: Sb. tezisov dokladov 41-kh Akademicheskikh chteniy po kosmonavtike, posvyashchennykh pamyati akademika S.P. Koroleva i drugikh vydayushchikhsya otechestvennykh uchenykh — pionerov osvoeniya kosmicheskogo prostranstva [Collection of reports abstracts for the 41st Academic readings on cosmonautics dedicated in memory of academician S.P. Korolev and other outstanding domestic scientists — pioneers of space exploration]. Moscow, BMSTU Publ., 2017, pp. 378−379.
[24] Altunin V.A., Altunin K.V., Aliev I.N., Shchigolev A.A., Yusupov A.A. Issledovanie vozmozhnosti primeneniya magnitnykh i elektrostaticheskikh poley dlya borby s osadkoobrazovaniem v aviatsionnykh motornykh maslakh dvigateley, energoustanovok i tekhnosistem nazemnogo, vozdushnogo i aerokosmicheskogo bazirovaniya [Researching the possible use of magnetic and electrostatic fields to address the problem of deposit formation in aviation oil for engines, power plants and technical systems of aircraft for aerial and aerospace use]. Izvestiya vuzov. Mashinostroenie — BMSTU Journal of Mechanical Engineering, 2017, no. 3 (684), pp. 76–88.
[25] Altunin V.A., Lvov M.V., Shchigolev A.A., Yusupov A.A., Koreev E.P., Yanovskaya M.L. Eksperimentalnoe issledovanie teplovykh protsessov pri vynuzhdennoy konvektsii aviatsionnykh motornykh masel [Experimental study of thermal processes during forced convection of the aviation motor oils]. In: “Sovremennye problemy raketnoy i kosmicheskoy tekhniki”: materialy polnykh dokladov na sektsii No. 2 “Problemy raketnoy i kosmicheskoy tekhniki” 57kh nauchnykh chteniy, posvyashchennykh razrabotke nauchnogo naslediya i razvitiyu idey K.E. Tsiolkovskogo (21 sentyabrya 2022 g., g. Kaluga, GMIK) [Modern problems in rocket and space technology: collection of full reports at Section no. 2 “Problems of the rocket and space technology” of the 57th scientific readings dedicated to development of scientific heritage and ideas of K.E. Tsiolkovsky (September 21, 2022, Kaluga, GMIC)]. Kazan, Shkola Publ., 2023, pp. 204−218.
[26] Lvov M.V., Yusupov A.A., Kaskov A.S., Shchigolev A.A. Analiz rezultatov issledovaniya vliyaniya magnitnykh i elektrostaticheskikh poley na teplovye protsessy v aviatsionnykh motornykh maslakh v usloviyakh estestvennoy konvektsii [Analysis of the results of a study of the influence of magnetic and electrostatic fields on thermal processes in the aviation engine oils under conditions of natural convection]. VOENMEKH. Vestnik BGTU — Journal “VOENMEH. Bulletin of BSTU”, 2018, no. 45, p. 23.
[27] Altunin V.A., Lvov M.V., Kaskov A.S., Shchigolev A.A., Yanovskaya M.L. Analiz effektivnosti primeneniya elektrostaticheskikh poley v sushchestvuyushchikh i perspektivnykh sistemakh smazki dvigateley letatelnykh apparatov vozdushnogo i aerokosmicheskogo bazirovaniya [Analysis of the effectiveness of the use of electrostatic fields in existing and future lubrication systems for engines of airborne and aerospace-based flying vehicles]. In: Trudy 54-kh chteniy, posvyashchennykh razrabotke nauchnogo naslediya i razvitiyu idey K.E. Tsiolkovskogo. Sek. No. 2: “Problemy raketnoy – kosmicheskoy tekhniki”. (Kaluga, 17–18 sentyabrya 2019 g.) [Proceedings of the 54th Readings dedicated to development of scientific heritage and ideas of K.E. Tsiolkovsky. Section 2: “Rocket and Space Technology Problems”. (Kaluga, September 17–18, 2019)]. Kazan, Kazan University Publ., 2020, pp. 77−82.
[28] Altunin V.A., Lvov M.V., Shchigolev A.A., Kaskov A.S. Razrabotka novykh konstruktivnykh skhem sistem smazki dvigateley letatelnykh apparatov vozdushnogo i aerokosmicheskogo primeneniya [Development of new design schemes for lubrication systems for aircraft engines for air and aerospace applications]. VOENMEKH. Vestnik BGTU — Journal “VOENMEH. Bulletin of BSTU”, 2020, no. 62, pp. 312−313.
[29] Altunin V.A., Altunin K.V., Lvov M.V., Shchigolev A.A., Aliyev I.N., Yanovskaya M.L. Problemy sistem smazki aviatsionnykh dvigateley [Problems of lubrication systems of the aviation engines]. Teplovye protsessy v tekhnike — Thermal Processes in Engineering, 2021, vol. 13, no. 8, pp. 357−384.
[30] Altunin V.A., Lvov M.V., Kaskov A.S., Shchigolev A.A., Yanovskaya M.L. Problemy osadkoobrazovaniya v sistemakh smazki dvigateley letatelnykh apparatov [Recording problems in aircraft engines lubricating systems]. In: Sovremennye problemy raketnoy i kosmicheskoy tekhniki: sb. nauchnykh statey (polnykh dokladov) 56-kh nauchnykh chteniy pamyati K.E. Tsiolkovskogo po sektsii No. 2: “Problemy raketnoy i kosmicheskoy tekhniki” (Kaluga, 21–22 sentyabrya 2021 g.) [Modern problems of rocket and space technology: collection of scientific articles (full reports) of the 56th scientific readings devoted to the memory of K.E. Tsiolkovsky, Section no. 2 “Rocket and Space Technology Problems”. (Kaluga, September 21–22, 2021)]. Kazan, Redaktsionno-izdatelskiy Tsentr Shkola Publ., 2022, pp. 99−113.
[31] Altunin V.A., Lvov M.V., Shchigolev A.A., Yusupov A.A., Yanovskaya M.L. Raschet plotnosti motornogo aviatsionnogo masla marki MS-20 pri razlichnykh temperaturakh i davleniyakh [Calculation of the density of motor aviation MS-20 brand oils at various temperature and pressure]. Inzhenerny zhurnal: nauka i innovatsii — Engineering Journal: Science and Innovation, 2023, iss. 2. https://doi.org/10.18698/2308-6033-2023-2-2252
[32] Lvov M.V., Altunin V.A., Yusupov A.A., Pukachev I.R., Yanovskaya M.L. Rezultaty eksperimentalnykh issledovaniy teplovykh protsessov v motornykh aviatsionnykh maslakh dvigateley letatelnykh apparatov [Results of experimental studies of thermal processes in aviation motor oils of the flying vehicles engines]. In: Sb. tezisov dokladov 47-kh Akademicheskikh chteniy po kosmonavtike, posvyashchennykh pamyati akademika S.P. Koroleva i drugikh vydayushchikhsya otechestvennykh uchenykh — pionerov osvoeniya kosmicheskogo prostranstva [Collection of abstract of the reports of the 47th Academic readings on cosmonautics, dedicated in memory of academician S.P. Korolev and other outstanding domestic scientists — pioneers of space exploration]. Moscow, BMSTU Publ., 2023, vol. 1, pp. 370−372.
[33] Altunin V.A., Lvov M.V., Shchigolev A.A., Yusupov A.A., Yanovskaya M.L. Eksperimentalnaya ustanovka dlya issledovaniya vliyaniya elektrostaticheskikh poley na teploobmen i protsess osadkoobrazovaniya v motornom aviatsionnom masle pri ego vynuzhdennoy konvektsii [Experimental installation for the study of the influence of electrostatic fields on heat exchange and the process of sedimentation in motor aviation oil with its forced convection]. Izvestiya vysshikh uchebnykh zavedeniy. Mashinostroenie — BMSTU Journal of Mechanical Engineering, 2023, no. 7, pp. 113–123. https://doi.org/10.18698/0536-1044-2023-7-113-123
[34] Altunin V.A., Lvov M.V., Yusupov A.A., Shchigolev A.A., Pukachev I.R., Yanovskaya M.L. Rezultaty eksperimentalnykh issledovaniy teplovykh protsessov v usloviyakh vynuzhdennoy konvektsii motornogo aviatsionnogo masla marki MS-20 [Results of experimental study of the thermal processes at forced convection of the MS-20 engine aviation oil]. Inzhenerny zhurnal: nauka i innovatsii — Engineering Journal: Science and Innovation, 2023, iss. 6. https://doi.org/10.18698/2308-6033-2023-6-2285
[35] Altunin V.A., Lvov M.V., Yusupov A.A., Shchigolev A.A., Koreev E.P., Yanovskaya M.L. Analiz metodiki rascheta teplootdachi k motornomu aviatsionnomu maslu marki MS-20 v usloviyakh vynuzhdennoy konvektsii v koltsevom kanale s uchetom ikh verifikatsii s eksperimentom [Analysis of the methods for calculating heat transfer in regard to the MS-20 brand motor aviation oil under conditions of forced convection in the ring channel given their verification with the experiment]. Inzhenerny zhurnal: nauka i innovatsii — Engineering Journal: Science and Innovation, 2023, iss. 7. https://doi.org/10.18698/2308-6033-2023-7-2293
[36] Gainullina L.R., Tutubalina V.P. Gazostoykost’ i termostabil’nost’ transformatornykh masel v elektricheskom pole [Gas stability and thermal stability of transformer oils in electric fields]. Vestnik YUUrGU. Ser. Energetika — Bulletin of South Ural State University. Series “Power Engineering”, 2018, vol. 18, no. 3, pp. 46–51. DOI: 10.14529/power180306
[37] Altunin V.A., Lvov M.V., Shchigolev A.A., Yusupov A.A., Koreev E.P., Yanovskaya M.L. Analiz metodik rascheta koeffitsienta teplootdachi k motornomu aviatsionnomu maslu v slozhnykh termodinamicheskikh usloviyakh aviatsionnykh i aerokosmicheskikh dvigateley [Analysis of methods for calculating coefficient of the heat transfer to aviation engine oil under complex thermodynamic conditions of the aviation and aerospace engines]. In: Materialy 58-kh Nauchnykh chteniy, posvyashchennykh razrabotke nauchnogo naslediya i razvitiyu idey K.E. Tsiolkovskogo. Sektsiya No. 2: “Problemy raketnoy i kosmicheskoy tekhniki”. (Kaluga, 19–20 sentyabrya 2023 g., GMIK im. K.E. Tsiolkovskogo) [Materials of the 58th scientific readings dedicated to development of the scientific heritage and ideas of K.E. Tsiolkovsky. Section 2: “Rocket and Space Technology Problems”. (Kaluga, September 19–20, 2023, State Museum of Culture named after K.E. Tsiolkovsky)]. Kaluga, Nasha Poligrafiya Publ., part 1, pp. 206–208.
[38] Altunin V.A., Lvov M.V., Yusupov A.A., Shchigolev A.A., Yanovskaya M.L. Rezultaty eksperimentalnogo issledovaniya teplovykh protsessov v sistemakh smazki dvigateley letatelnykh apparatov [Results of an experimental study of the thermal processes in lubrication systems of the flying vehicles engines].In: Sb. tezisov dokladov Mezhdunarodnoy nauchno-tekhn. konf. “Grazhdanskaya aviatsiya na sovremennom etape razvitiya nauki, tekhniki i obshchestva”, posvyashchennoy 100-letiyu otechestvennoy grazhdznskoy aviatsii (18–19 maya 2023 g., Moskva, MGTU GA) [Collection of abstracts of reports of the International scientific and technical conference “Civil aviation at the current stage of science, technology and society development» dedicated to the 100th anniversary of the domestic civil aviation (May 18-19, 2023, MSTU CA, Moscow)]. Moscow, ID Akademii imeni N.E. Zhukovskogo Publ., 2023, pp. 51–52.
[39] Altunin V.A., Lvov M.V., Yusupov A.A., Shchigolev A.A., Gortyshov Yu.F., Koreev E.P., Yanovskaya M.L. Rezultaty eksperimentalnogo issledovaniya vliyaniya elektrostaticheskikh poley ne teplovye protsessy v motornom avaiatsionnom masle marki MS-20 v usloviyakh ego vynuzhdennoy konvektsii. Chast 1 [Results of an experimental study of the electrostatic fields’ influence on thermal processes in the MS-20 aviation engine oil exposed to its forced convection. Part 1]. Inzhenerny zhurnal: nauka i innovatsii — Engineering Journal: Science and Innovation, 2023, iss. 11. http://dx.doi.org/10.18698/2308-6033-2023-11-2317
[40] Altunin V.A., Lvov M.V., Yusupov A.A., Shchigolev A.A., Gortyshov Yu.F., Koreev E.P., Yanovskaya M.L. Rezultaty eksperimentalnogo issledovaniya vliyaniya elektrostaticheskikh poley ne teplovye protsessy v motornom avaiatsionnom masle marki MS-20 v usloviyakh ego vynuzhdennoy konvektsii. Chast 2 [Results of an experimental study of the electrostatic fields’ influence on thermal processes in the MS-20 aviation engine oil exposed to its forced convection. Part 2]. Inzhenerny zhurnal: nauka i innovatsii — Engineering Journal: Science and Innovation, 2023, iss. 12. http://dx.doi.org/10.18698/2308-6033-2023-12-2324
[41] Nocedal Jeorge; Wright Stephen J. Numerical Optimization. 2nd edition, Springer, 2006. (ISBN 978-0-387-30303-1).
[42] Mikheev M.A., Mikheeva I.M. Osnovy teploperedachi [Basics of heat transfer]. 2nd ed., ster. Moscow, Energiya Publ., 1977, 343 p.